The PTO is rated at 485ft/lbs using one PTO and just over 600lb/ft for both. 180 ILL NO. We will not accept a return on ANY electronic items for any reason. Allison recommends that customers using TES 295 Approved Fluid consider Allisons newest fluid spec, TES 668, for their next service. But if so, why does the dipstick continue to show full after driving many, many miles? There a few things to be aware of so I thought I'd share. I have not done this before, but am going to do it in the next week. and when I tried to pour it back in with a funnel and a clear plastic hose, it fills the tube fast and runs out the top! In September of 1991, Allison Transmission Division launched the World Transmission product line with the release of the MD3060 automatic transmission into production. 982797. Mobil Delvac 1 ATF is recommended by ExxonMobil for use in: Call 1-800-662-4525 with product questions. Provides prompt and reliable lubrication at sub-zero ambient temperatures down to 54 C. Leads to viscosity retention even under the severest heavy duty, high temperature operating conditions. They also suggest fluid type, capacity, and filter #s. My Allison. MD3060P is my model. Contact us: I'll try that and give Freightliner a call also. If so, view our frequently asked questions below to find the answer you are looking for. Attn: Consumer Lubricants, Looking for the status of a rebate?Visit mobil.rebateresearch.com or call 1-866-895-9127. So sometimes you would be changing your filters without changing the fluid, I guess? Now I have 37,000. Truck Information Came From:? I read that it takes 29 quarts so I am curious about how many I will have to buy so as not to have too many extra gallons of $35.10 oil left over! All I can figure is that the PO filled it to capacity, not knowing any different. If you have any more questions please contact us. For some reason the dipstick always has transmission fluid about 6" above any mark, even though it is being checked when the fluid is cold. Yesterday we loaded up the motorhome and was backing up to hook up a trailer. These sources are the same for other fluids as well. Transmission Model. When you purchase through links on our site, we may earn an affiliate commission, which supports our community. Thanks to all and thank you BernieD for the 4 quart limit information, that almost had to be the answer, based on what I was seeing. PTO version is 32.49" long and weighs 575lbs. This website is not affiliated with or endorsed by the Airstream, Inc. or any of its affiliates. VerticalScope Inc., 111 Peter Street, Suite 600, Toronto, Ontario, M5V 2H1, Canada. Exceptional thermal and oxidation stability. Mechanics Corner - Engines, Transmission & More Airstream Trailer & Motorhome Owners Community, Currently Active Users Viewing This Thread: 1. . You can find links to relevant notices and more information about ExxonMobils privacy program, http://www.msds.exxonmobil.com/psims/psims.aspx, Privacy center (Do not sell or share my personal information), Other equipment requiring Allison TES-295 and TES-468 or MB-Approval 236.91 performance levels. I figured that it would be "easy" for me to be 1-2 quarts low, so I emptied the remainder (2 qts) of a partial gallon into the transmission which now makes 12 quarts total, expecting the sensor now to indicate 2 quarts low. If a fluid change is necessary, then you should switch to TranSynd (or one of the other TES-295 approved fluids) and change the filters to the new Allison "High Capacity" filters. Refunds will be applied once the inspection is complete and approved. Thanks to all. Regular fluid and filter maintenance is the simplest thing you can do to ensure the performance and durability of your Allison fully automatic transmission. The Allison Owner's manual is not really clear on this point. I torqued the bolts to 40. I guess it means you have to change your transmission fluid every 48 months even if it is Transynd? I agree to the Terms and Privacy*. If you copy the serial number, you can go the the Allison website and get all the info on your transmission. If you crawl underneath, there should be a metal plate with model and serial number on the driver's side of the transmission. Also fairly inexpensive for a rebuild or to find used. Is the dipstick wrong and the engine simply throws it out or burns it? 181 0 obj <>stream Thanks for understanding. For a better experience, please enable JavaScript in your browser before proceeding. The MD3060 came from a '98 motorhome/coach and it was attached to a P pump 5.9 Cummins 12v and as far as the harness it looks like one on the only inputs from the motor would be the TPS and a temp sender. The fluid is designed to meet the demanding requirements of modern heavy-duty automatic transmissions. However, if you drain the sump, additional fluid is required approaching 19 or so quarts, so the situation has been demystified. I've decided this is one of life's mysteries that I will never come to know, so as long as the engine is happy I buy the 7 gals of 15W40 and a new filter every year and pour myself an adult libation to celebrate when I'm done. The trans is currently behind a 5.9 cummins in a ford, but I am trying to figure out info on swapping to the dt466 I seem to remember a forum where there were some guys making internationals into 4x4's, anyone else know that forum? The filter holds about 1.2 quarts, so where did the rest go? Canada. Allison recommends TES 668 Approved Fluids to extend drain intervals and enhance transmission performance and durability in all operating environments. Allison Transmission TES 468 Approved Fluids are approved for use in Allison H 40/50 EP on-highway products and may be used anywhere a TES 295 product is specified. I hope you have enough room to work with. The clean part is then inspected for any defects that would make it unfit for sale. Also in some other old posts there was talk of having custom ECMs for allison 2400's and they were talking about 4 different companies that made parts for allison swaps. IMHO, a xmission that costs >15K, needs to be treated with caution. If you use the truck strictly for work, this is a great trans to use. Allison recommends TES 668 Approved Fluids to extend drain intervals and enhance transmission performance and durability in all operating environments. Hi Brett. As was said, these transmissions are HUGE! Allison Approved Fluids that are synthetic based offer improved viscosity that other fluids can't offer. FRICTION MODIFIER BY LUBEGARD, HAGERTY KB20 SNAPRESS Automatic Transmission Clutch Spring Compressing Tool UPDATED VERSION, HAYDEN 405 TRANSMISSION OIL COOLER FITS FULLSIZE VEHICLES: 15.5" x 10", LUBEGARD COMPLETE FULL SYNTHETIC ATF AUTOMATIC TRANSMISSION FLUID 3 QUARTS (69032), LUBEGARD COMPLETE FULL SYNTHETIC ATF AUTOMATIC TRANSMISSION FLUID 6 GALLONS (22.71L)(69005), LUBEGARD KOOLER KLEEN AUTOMATIC TRANSMISSION COOLER FLUSH (WATER BASED) 18oz CAN (19025), LUBEGARD PLATINUM UNIVERSAL AUTOMATIC TRANSMISSION FLUID PROTECTANT 10oz, SHOP FLOOR OIL DRY, NATURAL NON-HAZARDOUS Diatomaceous Earth 25lb BAG, TRANSMISSION OIL COOLER LINE REPAIR KIT FOR 5/16" & 3/8" LINES WITH 80pcs & 15' OF HOSE, TRANSMISSION VALVE-BODY CLEANING 4-PIECE BRUSH SET WITH 5/8", 7/8", 1-1/8", 1-3/8" BRUSHES, TRANSMISSION, TRANSFER CASE, OR DIFFERENTIAL ASSEMBLY LUBE: BLUE LOW-TACK 16oz TUB, TRANSMISSION, TRANSFER CASE, OR DIFFERENTIAL ASSEMBLY LUBE: GREEN HI-TACK 16oz TUB, TRUCOOL LPD4454 TRANSMISSION OIL COOLER 11"x 7.25" x.75" LOW PRESSURE DROP 18K GVW ALUM, UNIVERSAL FIT AUTOMATIC TRANSMISSION OIL PAN DRAIN PLUG KIT FITS DODGE FORD GM. endstream endobj 183 0 obj <>stream Gary, Here is the end of the story! Introducing the next generation of synthetic on-highway automatic transmission fluid, Allison Transmission TES 668. Allison TES 668 Approved Fluids are recommended for use in Allison 1000 Series, 2000 Series, 3000 Series, 4000 Series and H 40/50 EP on-highway products. If you are the site owner (or you manage this site), please whitelist your IP or if you think this block is an error please open a support ticket and make sure to include the block details (displayed in the box below), so we can assist you in troubleshooting the issue. Copyright 1999 2023 GoDaddy Operating Company, LLC. Cookies are small text files that can be used by websites to make a users experience more efficient. Allison Transmission (A 629 540 43 00) On-board diagnostics, 15. DESCRIPTION YEARS QTY PART NO Allison 3000 Series, MD3060, MD3656 HARD PARTS 801A Piston, Lock-up Apply (MD3060) 1 MD3060.PIS01 NI Cover/Diaphragm With Seal . . We will call you for shipping & payment information. is rated (and warrantied) for. Really have a lot of hold back all the way down low. Best Way To Siphon Gas From My 2019 E450 Class C? Anybody ever anything to do with the Allison MD3060 6 speed tranny? So I'm askingis the 10.5 qt the correct value for the shallow (2") pan? Qty 1. Any help will be appreciated. Allison 1000 Transmission Fluid Capacity You may get tired of hearing this, but there are three good sources for knowing your Allison transmission fluid capacity. Often, restricted air flow through the CAC and radiator causes your symptoms and a simple cleaning can restore your cooling system to its original capacity. I think I would replace what I took out and be done with it. I spend countless hours stuck in hotel rooms with my job and over research these things to kill time. Come join the discussion about trail reports, builds, performance, modifications, classifieds, troubleshooting, fabrication, drivetrain, and more! Glad that one is solved. I don't know too much, but I read the torque on the filter bolts was 37-43 FT lbs? The customer will pay the shipping cost for the return of the item. Now I will attempt to finish the job. Surrey, BC V3T 2T1 The tranny is awfully large though you guys are right about that. JavaScript is disabled. Most of the Allison literature indicates the onboard system is far more accurate than the dipstick, but the dipstick would give an "estimate" of fluid content. Go with synthetic trans fluid. Keeps transmissions clean to extend life and performance even under some of the harshest driving conditions. ~Gyn|YDpQ K>1\T3 ;Q' adn2@&7]OFTz0W Pmg5d;TZgb3HHk[FM5yZHElt>Qm9t\w_X!L I don't know if that even figures into this operation. Then you won't have to do it again for 100,000 miles. A 3060 in a typical tractor application was rated (and well warrantied) to 80k gcw with the 285/800 limits which is almost 4 times what a 47RE etc. I thought that I would lose a lot more than that. I caught all the old fluid and it looked like a lot, so i measured it to see how much and it was damned close to 19 quarts, the listed "capacity" of this transmission. DESCRIPTION YEARS QTY PART NO ILL NO. By signing up for ExxonMobil Lubricants marketing communications using this form, you agree to accept the frequency of communications as deemed appropriate by our campaign manager. Thanks for the tip on leaving one of the bolts in so I don't get a bath. In January of 1996, Allison introduced the MD3066 transmission, the next response to market trends in automatic transmissions for use in trucks. Allison Transmission Lubricant Capacities. Mobil Delvac 1 ATF advanced technology has demonstrated extended drain, long-term friction retention, and low-temperature capability. This product has the following approvals: VOITH TURBO DIWA Service Bulletin 013 -Extended Drain, VOITH TURBO DIWA Service Bulletin 118 - Extended Drain, Brookfield Viscosity @ -40 C, mPa.s, ASTM D2983, Kinematic Viscosity @ 100 C, mm2/s, ASTM D445, Kinematic Viscosity @ 40 C, mm2/s, ASTM D445, Health and Safety recommendations for this product can be found on the Material Safety Data Sheet (MSDS) @ http://www.msds.exxonmobil.com/psims/psims.aspx. Faster shipping methods are available at an additional cost. You can find links to relevant notices and more information about ExxonMobils privacy program here. I have a MD3000MH transmission in my Horizon and drained it via drain plug and removed the filters to replace them. How is a tranny that huge and from a MH only rated at 275hp?? Looking to Purchase this Part? Not sure when last service was done on engine, so I'm changing out all the fluids and filters. On Shelf . Work Order. $62.88 $54.77 $69.95. I measured the amount that I drained out (1/2 gal.) Enhanced, long-term frictional properties. Read our Mobil Delvac and Mobil Delvac 1 product-related frequently asked questions. If you are unsure, call Allison with your transmission serial # and they can tell you. The BestCounty Park CampgroundsFor RVe Where Can I Have Packages Delivered While On The R Plan Your RV Route & Find Campgrounds Like a P Don't Miss Carolina Pines RV Resort In South Carol Know How To Prevent A Space Heater Fire In Your RV. The website cannot function properly without these cookies. You are using an out of date browser. Huntsville, AL I have a MD3000MH transmission in my Horizon and drained it via drain plug and removed the filters to replace them. CITGO SynDurance 668 Automatic Transmission Fluid, SK HD 668 Fully Synthetic Automatic Transmission Fluid, Valvoline Syn Gard 668 Automatic Transmission Fluid, Rugged 668 HD Synthetic Transmission Fluid, HD SYN DRIVE Full Synthetic Transmission Fluid, PurTrax Heavy Duty Synthetic Automatic Transmission Fluid, Mobil Delvac Synthetic ATF / Mobil Delvac 1 ATF, Transtar Allison TES Certified Full Synthetic ATF, John Deere - HD Synthetic Transmission Fluid, Castrol ATF Heavy Duty / Transmax ATF Heavy Duty, Vehicle Electrification + Environmental Test Center. Gary, you hit the nail on the head and it is good information for others who might attempt servicing their own transmission. It's pretty much "fill for life". What's The Best Cordless Vacuum For RVers? The Allison that's the top dog (for a DT466)would be the MD3060. This discussion is proudly sponsored by: Please support our sponsors and let them know you heard about their products on iRV2 Thread Tools Join the #1 RV Forum Today - It's Totally Free! Thanks! 12905 King George Blvd I read something about an Internal filter that I will have to ask the service manager about when I buy the parts. The first is to check your owner's manual to see what the manufacturer says. Thanks Gary. The MD3060 came from a '98 motorhome/coach and it was attached to a P pump 5.9 Cummins 12v and as far as the harness it looks like one on the only inputs from the motor would be the TPS and a temp sender. The torque converter being programed to hold lock for use with an exhaust brake is a very nice feature on these transmissions. I need to tackle that project as well!!! A forum community dedicated to custom off-road vehicle owners and enthusiasts. Our Website may also enable third-party tracking mechanisms to collect data over time and across unaffiliated websites for use in interest-based marketing. Re: Allison MD3060P Specs Reply #3 on: April 03, 2013, 11:52:13 AM Non PTO 3000 series is 28.29" long and weighs 535lbs. Mail us at:ExxonMobil Fuels & Lubricants Company I had a transmission fluid . Most MD3060 (at least the shallow sumps) take around 19 quarts for a chance (not initial fill). Allison recommends that customers using TES 389 Approved Fluid consider Allisons newest fluid spec, TES 668, for their next service. For a better experience, please enable JavaScript in your browser before proceeding. This discussion is proudly sponsored by: Please support our sponsors and let them know you heard about their products on iRV2 Thread Tools Join the #1 RV Forum Today - It's Totally Free! The reason I am looking at the MD3060 is there is one close I can pick up for the same cost as an Allison AT545. If you would like to discuss it further, you can contact me directly. 99 Truck Parts Call for Price Plus Shipping & Handling. The tranny is awfully large though you guys are right about that. In order of favorables: #1, MD3060 #2 . allison md-3060 md-3560 transmission parts & rebuild kits. Simply let our friendly salesperson know your preference when you place your order. Anyone else have high fluid on their dipstick? Significant wear reduction and long transmission life. For a better experience please use a browser other than your current version of Internet Explorer. The synthetic base oil composition enables excellent performance even in some of the harshest operating conditions. The transmission went into neutral and the shift panel display for the Allison went blank. 99 Truck Parts provides ground shipping to the United States (lower 48) and across Canada on most parts. Reduced concern in top-off situations and excellent seal materials leakage control. You can find links to relevant notices and more information about ExxonMobils privacy program here. The Allison Owner's Manual (OM33459EN, copyright March 2000, page 40) that came with the MH, states a transmission fluid refill capacity of "3000 MH/MD 3060 2-inch sump as 10.5 quarts" It offers outstanding gear shifting and power transfer performance. I guesss it wouldn't be so bad if I had known what I know now. My next plan is to take a highway run and then check for any leaks, and use the electronic indicator to tell me if it is OK. Why would the dipstick always register so high on the dipstick when it is cold? If so, call them (1-800-FTL-HELP) with your VIN number and they can tell you what the capacity of your transmission is and how much fluid you should add on a filter change. I have had Transynd put in several years ago. Location 21C2. The drain plug I removed was not on the torque converter and was located in the transmission cast aluminum pan. If you have any adivce you can give me on this I would appreciate it. Shipping is done through Canada Post and is usually delivered in 4 or 5 business days. The cold check mark is only about 1 1/2 in from the end of the dipstick. Health and Safety recommendations for this product can be found on the Material Safety Data Sheet (MSDS) @, Your privacy is important to us and we want you to understand our practices with respect to the gathering and handling of your personal data. Allison Transmission TES 295 Approved Fluids are approved for use in Allison 1000 Series, 2000 Series, 3000 Series, 4000 Series and H 40/50 EP on-highway products. Gary. Thought you would be interested in this article/resource and could find it useful. This enables us to make the structure, navigation, and content of our Website as user friendly as possible. http://www.cumminsforum.com/forum/98-5-02-powertrain/41978-nv5600-fso6406a-6-speed-fuller.html, http://pirate4x4.com/forum/showthread.php?t=903103, http://howards-conversions-allison.com/products.php?id=all. Airstream is a registered trademark of Airstream Inc. All rights reserved. Thanks everyone for all the replies. We also share information about your use of our site with our social media, advertising and analytics partners who may combine it with other information that youve provided to them or that theyve collected from your use of their services. Thanks Gary. Thread Tools Display Modes On the road and the engine will not idle | Top | P30 split diagonal brake system? Allison 3000 Transmission Fluid Capacity The capacity has not changed in the last few sentences. compare forum.dieselrvclub.org/index.php?topic=7495.0, Mozilla/5.0 (iPhone; CPU iPhone OS 15_5 like Mac OS X) AppleWebKit/605.1.15 (KHTML, like Gecko) Version/15.5 Mobile/15E148 Safari/604.1. Allison Transmission TES 389 Approved Fluids are approved for use in traditional on-highway products.

Arkansas Stand Your Ground Law Explained, Handgun Purchase Permit Otoe County, Articles A